NCCCO Overhead Crane Test Latest Update

NCCCO Overhead Crane Test Latest Update

• 100 Questions and Verified

Correct Answers Guaranteed A+ At First Attempt

3 wraps - Correct Answer:According to OSHA, how many wraps must be left on the

hoist drum of an overhead crane with the hook at its lowest position?

3,800 lbs - Correct Answer:Steel Plate weighs 40 pounds per inch, What is the

approximate weight of a steel plate 8 ft. long, 5 ft. wide and 3 inches thick?

3.5 to 1 - Correct Answer:What is the minimum safety factor for overhead crane wire ropes?

4,500 pounds - Correct Answer:An object weighs 150 pounds per cubic foot, it

measures 5' long X 3' wide X 2' high, how much does it weigh?

• to 1 - Correct Answer:According to ASME B30.2, what is the safety factor for rigging?

5,400 lbs - Correct Answer:An object weighs 150 lbs per cubic foot and measures 4 ft. X

• ft. X3 ft., what is its weight?

6 strands with 19 wires - Correct Answer:A wire rope designated as 6 X 19 has?

10 degrees - Correct Answer:According to ASME B30.2, the maximum twist of the hook can't exceed?

10BC - Correct Answer:According to ASME B30.2, what type of fire extinguisher is required for overhead cranes?

15% of its original size - Correct Answer:According to OSHA, the maximum hook throat opening must not exceed what?

30 cubic feet - Correct Answer:An object to be lifted is rectangular in shape and measures 5' long x 3' wide x 2' high. What is the volume of this object?

30 cubic feet - Correct Answer:How many cubic feet is in a rectangular object that measures 5 ft. X 3 ft. X 2 ft.?

1910.184 - Correct Answer:Which OSHA regulation listed below can you find

information about hoisting slings?

• 1910.184
• 1910.550
• 1910.180 1 / 2

• 1910.601

a shackle - Correct Answer:Whenever a situation calls for placing both ends of a sling into a hook or placing more than one sling into a hook, what piece of rigging hardware for making this connection should be used?

all legs don't always share equal parts of the load - Correct Answer:What precaution should be observed when using 3 and 4 legged bridles?

alloy - Correct Answer:According to OSHA, what type of chain should be used by an overhead crane?

an area where it will not cause an unsafe condition - Correct Answer:Overhead cranes should be parked in?

anyone - Correct Answer:In the event of an emergency, who may give the stop signal?

ASME B30.2 - Correct Answer:Which of the following standards applies to overhead cranes?a)OSHA 1910.134 b)ASME B30.5 c)PCSA 1926.550 d)ASME B30.2

ASME B30.20 - Correct Answer:Which of the ASME standards listed are for below the hook lifting devices?

a) ASME B30.20

b) ASME B30.19

c) ASME B30.79

d) ASME B30.10

B30.2 - Correct Answer:What is the ASME volume that pertains to overhead cranes?

basket, vertical, choker - Correct Answer:What is the order of hitch strength?

breaking strength divided by safety factor - Correct Answer:What is the safe working load (SWL) of a wire rope defined as?

bridge and trolley controller - Correct Answer:A swinging load should be controlled by the?

bridge or trolley controls - Correct Answer:Swinging loads can be controlled by the use of the ?

bridge travel - Correct Answer:When given the signal (stop signal), what will the operator do?

• / 2